Emerson Liebert ICOM-DO Manual de instalación descargar pdf (Pagina 10)

Liebert CRV Component Location

Figure 3 Component location - Liebert CR035, CR020 water/glycol-cooled units

Figure 4 Component location - Liebert CR040 chilled water units

1 Top water/glycol connections

2 Compressor

3 Brazed plate condenser

4 Bottom water/glycol connections

5 Water/glycol valve

6 Refrigerant receiver

7Air filters

1 Top CW connections

2 Air filters

3 Three-way CW valve

4 Bottom CW connections

5 Humidifier

1 2 ... 5 6 7 8 9 10 11 12 13 14 15 ... 87 88

Chilled Water 1
TABLE OF CONTENTS 3
SAVE THESE INSTRUCTIONS 7
IEBERT CRV COMPONENT LOCATION 9
2.0 INTRODUCTION 11
3.0 INSPECTION AND UNPACKING 12
Spreader Bars and Slings 14
Piano Jacks 14
Forklift 14
3.5 Removing the Piano Jacks 16
5.0 LIEBERT ICOM CONTROL 19
5.2.2 CAN Bus Termination 22
Liebert iCOM Control 23
Termination Jumper 23
Wall-Mount Large Display 25
Liebert iCOM 26
I/O Board 26
Large Graphics Display 26
(Rear View) 26
5.5 Alarms/Events 31
6.0 PIPING 32
INCORRECT 33
General Guidelines 34
7.0 REFRIGERANT CONNECTIONS 35
UNIT AREA 37
7.2.1 General layout 38
Table 8 Condenser positioning 39
Figures 29 and 30 40
7.2.3 Installing Piping 41
Refrigerant Connections 42
Liquid Line Connection 42
Thermostatic Valve Connection 42
Variable Fan Speed Charging 43
8.0 WATER CONNECTIONS 44
8.2 Glycol Mixture 45
Liebert CRV 46
9.0 ELECTRICAL CONNECTIONS 48
Wiring Connections 49
Electrical Connections 50
°F / -5/+70°C) 51
°F / 60°C 51
10.0 STARTUP 53
10.2 Automatic Restart 54
11.0 OPERATION 56
12.2 Environmental Protection 57
13.0 MAINTENANCE 58
13.5.1 Condensate drain 60
13.7 Electrical Heaters 61
13.8 Dismantling the Unit 62
Maintenance 63
14.0 TROUBLESHOOTING 64
APPENDIX A-HUMIDIFIER 65
7/8" Drain 66
Connection 66
3/8" Cold Water 66
Olive Connection 66
A.1.4 Low Water Conductivity 67
A.1.5 Cylinder Replacement 67
Remove the Old Cylinder 68
Installing the New Cylinder 68
Humidifier Maintenance 68
A.2 STARTING POINT 69
Humidifier 70
APPENDIX B-ELECTRICAL DATA 72
(Distance) D = A + B + C 73
CDT = Conditioner 73
COND = Condenser 73
Installation Drawings 75
REAR VIEW 76
DPN001884 81
DPN001984 82
DPN001985 83
SL-11975_REV2_12-09 88

Comentarios a estos manuales

Sin comentarios

Emerson Liebert ICOM-DO Manual de instalación Pagina 10

Comentarios a estos manuales

Relacionado con productos y manuales para Redes Emerson Liebert ICOM-DO